SeaDoo GTI LE Specifications Page 80
- Page / 130
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
80
MAINTENANCE CHART
The maintenance is very important, if you are not familiar with safe service prac-
tices and adjustment procedures, see your authorized SEA-DOO dealer.
Periodic Inspection
Routine maintenance is necessary for all mechanized products. A periodic inspec-
tion contributes to the product’s life span.
The following maintenance chart gives guidelines for regular watercraft servicing
scheduled to be performed by you and/or by an authorized SEA-DOO dealer. The
schedule should be adjusted according to operating conditions and use.
IMPORTANT: Schedule for watercraft rental operations or higher number of hour
use, will require greater frequency of inspection and maintenance.
DESCRIPTION FREQUENCY
I: Inspect, verify, clean, adjust, lubricate,
replace if necessary
C: Clean
L: Lubricate
R: Replace
FIRST
10 HOURS
EVERY
25 HOURS OR
3 MONTHS
EVERY
50 HOURS OR
6 MONTHS
EVERY
100 HOURS OR
1 YEAR
TO BE
PERFORMED BY
GENERAL
Lubrication/corrosion protection ➀ L C
ENGINE
Support and rubber mount IID
Exhaust system fasteners ➄ IID
RAVE valve (if so equipped) ➄ CCD
Top end (leak test, piston and ring clearance)
(DI models only) ➄
➈ D
Counterbalance shaft oil level (if so equipped) IID
Spark plug I➃ R D
Ignition timing (all models except DI) ➄ I D
TDC setting (DI models only) ➄➈D
COOLING SYSTEM
Flushing C ➂ C
Hose and fasteners IID
Engine drain tubes I ➀ C
Water flow regulator valve (if so equipped) I D
smo2004-002a.book Page 80 Thursday, August 21, 2003 2:54 PM
www.SeaDooManuals.net
- WARNING 2
- FOREWORD 3
- TABLE OF CONTENTS 4
- INTRODUCTION 9
- SAFETY CHECK LIST 10
- GETTING UNDERWAY 11
- SAFETY INFORMATION 11 12
- To Bring 13
- OPERATION 14
- Operator/Passenger 15
- Awareness 15
- Maneuverabitily of the 15
- Watercraft/Towing 15
- OPERATING RULES 16
- WATERSKIING SIGNALS 17
- WEB SITES 18
- SAFETY INFORMATION 19 20
- 20 SAFETY INFORMATION 21
- XP DI Models 21
- SAFETY INFORMATION 21 22
- Label 1 22
- 22 SAFETY INFORMATION 23
- SOME MODELS 25
- TYPICAL — SOME MODELS 25
- INFORMATION 26
- REGISTRATION NUMBER LOCATION 27
- IDENTIFICATION NUMBERS 28
- 947 DI Engine 29
- MAGNETO side 29
- GTI and GTI LE Models 31
- GTI RFI Models 31
- GTI LE RFI Models 32
- FUNCTIONS 35
- 1. Engine start/stop button 37
- 1. VTS button 37
- 1. Choke lever 37
- 1. Position indicator 40
- 2. Bow up 40
- 3. Bow down 40
- 11) Glove Box 41
- 15) Front Storage 43
- Compartment Cover 43
- 2. Retaining strap 44
- 1. Seat latch 44
- 21) Seat Extension Latch 45
- (if so equipped) 45
- 22) Rear Grab Handle 46
- 23) Rear Storage Basket 46
- 24) Bow and Stern Eyelets 46
- ALL MODELS EXCEPT XP DI 47
- 1. Mooring cleats 47
- 1. Boarding step 47
- 30) Cooling System Bleed 48
- 31) Flushing Connector 48
- 32) Bilge Drain Plugs 48
- BREAK-IN PERIOD 53
- PRE-OPERATION CHECKS 54
- Storage Compartment 57
- Covers and Seat 57
- Safety Lanyard and Engine 57
- Start/Stop Button 57
- OPERATING INSTRUCTIONS 58
- 3. Nozzle up 60
- 2. Bow down 61
- 3. Nozzle down 61
- Boarding the Watercraft 62
- Starting 64
- Rough Water or Poor 65
- Visibility Operation 65
- Crossing Waves 65
- Stopping/Docking 65
- Beaching 66
- Shutting Off the Engine 66
- POST-OPERATION CARE 67
- Anticorrosion Treatment 69
- SPECIAL PROCEDURES 70
- Capsized Watercraft 71
- Fuel-Flooded Engine 73
- Out of Fuel 74
- Towing the Watercraft in 74
- Low-Charge Battery 76
- Condition 76
- MAINTENANCE 77
- Engine Emissions 78
- Information 78
- MAINTENANCE CHART 80
- 1. Front tab 84
- 2. Rear mechanism 84
- VTS Adjustment 86
- Vacuum Bailer Pick-Ups 86
- 1. Electrical box 90
- 1. Fuse holder 90
- 1. Electric bilge pump fuse 90
- O.P.A.S. System 91
- General Inspection and 91
- Cleaning 91
- TRAILERING, STORAGE 92
- AND PRESEASON PREPARATION 92
- 1. Vent tube support 95
- 1. Bleed outlet hose 99
- Preseason Preparation 101
- TROUBLESHOOTING 103
- Engine Will Not Start 104
- Engine Overheats 105
- Engine Continually Backfires 105
- Engine Pinging or Knocking 105
- SPECIFICATIONS 107
- SI* METRIC INFORMATION 111
- WARRANTY 113
- LIST OF DISTRIBUTORS 114
- WARRANTY: 2004 SEA-DOO 115
- PERSONAL 115
- WATERCRAFT 115
- PERSONAL 121
- CHANGE OF ADDRESS/OWNERSHIP 125
- CHANGE OF ADDRESS 126
- DEALER IMPRINT AREA 129
Related products and manuals for Engine SeaDoo GTI LE
Engine SeaDoo GS Operations Instructions
(109 pages)
(109 pages)
Engine SeaDoo GTI LE RFI Specifications
(121 pages)
(121 pages)
Engine SeaDoo GSX Limited User Manual
(11 pages)
(11 pages)
Engine SeaDoo XP DI Operations Instructions
(24 pages)
(24 pages)
Engine SeaDoo SP Service Manual
(316 pages)
(316 pages)
Engine SeaDoo GS Operations Instructions
(100 pages)
(100 pages)
Engine SeaDoo GSX Service Manual
(56 pages)
(56 pages)
© 2020, manymanuals.com. All rights reserved. | 1.009 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals